HomeMy WebLinkAboutB4-520 MSDS INFO 11-12-03.PDFMATERIAL SAFETY DATA SHEET
FOR COATINGS, RESINS,RELATED
IDATE OF PREP: November 12, 20031
1 E
MANUFACTURER'S
: ww NAME:
STREET ADDRESS: 4120 Hyde Parr Blvd., P.O. Box 786 CITY, STATE, AND ZIP CODE:
Niagara Falls, New York 14302
(for emergency info only)
PRODUCT CLASS: Varnish MANUFACTURER'S CODE IDENTIFICATION:
No. 130 Class "B" Semi -Gloss Fire
TRADE NAME: Flame Control Retardant Varnish Overcoat for No. 19
INGREDIENT 1
PERCENT
! ACGIH TLVI
OS PEL I
LEL !
VAPOR !
I
(
! P !
PPM I
I
PRESSURE
Mineral. Spirits P
52-57
! !
I NE * 1NE*
1
!
1
1.1 P
!
2.0 !
CAS 64742-88--7 P
I !
1
!
1
P
Calcined Siliceous Earth (
1-3
I P
1 NE (NE
I
I
NA 1
!
NA
CAS 68855-54-9 I
I I
I
!
I
The above product may contain !
10.05 mg/m3 1
0.05 mg/m3 !
NA (
NA !
Up to 63% cristobalite 1
HRESPIRABLEI
(RESPIRABLEJ
!
1
CAS 14464-46-1 !
CRISTO ITE)
CRISTOB ITE
!
(Crystalline Silica) !
! !
I
I
I
I
!
Antimony Oxide 1
1-3
I I
INE
I
0.5 mg/m3 1
!
NA 1
!
NA 1
CAS 1314-60-9 1
! I
as Sb I
I
!
1
* (Stoddard Solvent !
1
! I
! 100 1
! i
!
100) !
!
!
I
!
I
- - - - - - - - - - - - - - - - _ -
SECTION
_ _ _ _
III
_ _ _ _ _ a ® _ - - -!-
PHYSICAL DATA
- _I_
® - _ -
Boiling Range: 318-386F Vapor Density: Heavier than air
Evaporation Rate: Slower than ether Percent Volatile by Volume: 69
_ _ '
Weight Per Gallon: 7.77lbs. _ _ _ _ _ _ _ _ �
V.O.C..O.C. 4.4 lbs./gl.(527 /L)- _ _ _
SECTION IV FIRE EXPLOSIVE Z DATA
DOT CATEGORY: Paint FLASH POINT: 100E (37.8C) Closed Cup
Combustible liquid UN 1263 LEL: 0.7
IS INDEX: H=1, F=2, R-0
- 2 -
EXTINGUISHING MEDIA:
Foam, carbon dioxide, dry chemical
UNUSUAL FIRE AND EXPLOSION RAZARDS:
This material is combustible and may be ignited by heat,
electricity. sparks, flame and stab
SPECIAL FIRE FIGHTING PROCEDURES:
Water not ordinarily effective, solid hose streams tend to spread fire,
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
SECTION V HEALTH HAZARD DATA
THRESHOLD LIMIT VALUE: See Section II
EFFECTS OF OVEREXPOSURE:
Irritating to eyes, defatting to skin; rated slight irritant,
Notice: Reports have associated repeated and Prolonged occupational overexposure tc
solvents with permanent brain and nervous system damage. Intentional misuse by
deliberately concentrating and inhaling the vapors may be harmful or fatal. Medical
conditions which may be aggravated: Pre-existing upper respiratory and lung disease such
as, but not limited to bronchitis, emphysema, asthma,
Chronic Health Effect: Crystalline silica has been classified as carcinogenic for humans
(1) by IARC, It has not been classified as a carcinogen by NTP or OSHA, rystalli
silica is also a known cause Of silicosis, a noncancerous lung disease Cused
ne
by
excessive exposure to crystalline silica. caused
-P_rima Ent : Inhalation,
EMERGENCy AND FIRST AID PROCEDURES:
Remove from further exposure, flush affected skin area with water or mild soap and water.
Flush eyes with gentle stream of water. See a doctor,
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
SECTION VI - -ACTIVITY DATA - - - - -
STABILITY: Stable
CONDITIONS TO AVOID: Excessive heat, sparks, open flame,
INCOMPATIBILITY (MATERIALS TO AVOID}; Strong acids or bases,
oxidizing agents,
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition in the Presence of air may yield
carbon monoxide and/or carbon dioxide,
HAZARDOUS POLYMERIZATION: Will not occur
- - - - - - - - - - - - - - - - - - - - - - - - - - - SECTION vII SPILT.- - - - - - - - - - - - - - - - - -
OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
Wipe up immediately and discard saturated absorbents. In event Of large
area and Pump material into waste tank, remove any spills, dike
vapors. source of ignition, avoid breathing of
WASTE DISPOSAL METHOD:
Dispose of - in accordance with local, state and federal regulations.
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
® 3 -
mmna��t
w.
SCOHNIS1
RESPIRATORY PROTECTION:
Self contained breathing equipment, air respirator or air mask where there is an oxygen
deficiency.
VENTILATION:
Local Exhaust; Explosion proof type.
PROTECTIVE GLOVES: Yes
EYE PROTECTION: Chemical safety goggles or face shield.
OTHER PROTECTIVE EQUIPMENT: All motors and switches should be explosion proof.
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
SECTION IX SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING:
Material is classified as a combustible liquid, Keep away from heat and open flame. Use
with adequate ventilation. Avoid contact with skin. Do not store at temperatures above
100F.
OTHER PRECAUTIONS:
Avoid skin contact and breathing of vapors and sanding dust. Use with adequate
ventilation.
- - - - - - - - - - - - - - - - -
Section 313 Supplier Notification
This product contains the following toxic chemicals subject to the reporting requirements
of Section 313 of the Emergency Planning and Community Right -To -Know Act of 1986 and of
40 CFR 372:
CAS # Chemical Name Percent by Weight
1314-60-9 Antimony Oxide 1-3
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
The information contained herein is based on the data available to us and is believed to be correct. However, we
make no warranty, expressed or implied regarding the accuracy of this data or the results to be obtained fron
the use thereof. Flame Control Coatings, Inc. assumes no responsibility for injury from the use of the product
described herein.