HomeMy WebLinkAboutBLDC-9-10-10975 SCOPE OF WORK.tif � C _��io
Store #: 3954 Scope of Work
Program FRESH - Scope of Work
Store #:3954 — Hickory, NC Date: August 11, 2010
Type: Gold (e) wall finish: Sheet rock and tile
General Notes:
• Remove interior mirrors throughout sales floor.
• Remove all egg crate tiles and associated grid above coffee and beverage areas. Repair all damaged areas.
• Repair existing VCT the floor in sales floor as needed.
• Repair existing quarry tile floor sales floor as needed.
• Provide and install black rubber base around perimeter of sales floor in locations where rubber base r'
currently exist. Areas with tile base shall remain in tact unless otherwise noted.
• Provide electrical circuits for all new equipment shown on plan. Use existing circuits when available.
• Relocate electrical circuits and water connections with any relocated equipment.
• Clean up all exposed electrical conduit and WAN cabling throughout sales area.
f
• While re- finishing interior sales floor walls, be sure to keep all equipment access panels and doors in
operating condition.
• Review all trash cabinets and install "TRASH" decals on swinging doors if they do not currently exist.
Decals provided by The Pantry.
• Receive and install Mens and Womens restroom identification signs provided by The Pantry.
• GC is responsible for thorough cleaning of store upon completion of work.
Exterior Work
100) Exterior re- imaging provided under a separate scope of work.
101) Pressure wash site, building and canopy. Re- stripe parking lot.
102) Pressure wash and clean interior of car wash bay.
103) Paint exterior man doors beige.
104) Paint where awning have been removed on exterior of building.
105) Replace metal door to car wash equipment room.
General Sales Floor Work
200) Remove all existing interior wall graphics and wood trim pieces. Prep sheetrock walls to a level 3
sheetrock finish and prepare to receive wall covering. G. C. to receive and install Koroseal Boothill
Bisque 5121 -31 per decor plans.
f
201) Paint back room door, restroom doors and associated door frames black. ICI / Devoe Coatings K -4a
Black, Devflex HP Acrylic S /G, 4216 -9990 gallon, black — No Tint. Install Wilsonart 1595 -01 Gloss Black f
t
plastic laminate over the door faces. Provide and install a 12" high stainless steel kickplate on both
r
sides of all doors. (Laminate by The Pantry, kickplate, door hardware and paint by G.C.)
)
Printed: 08/13/10 Master updated: 7/2/10 Page 1 of 5
Store #: 3954 Scope of Work
• Hollow Metal Door Frames
Hollow Metal Door and Ptame surfaces shall be solvent wiped in accordance with SSPC SP -1 F
I
starldards to remove all contaminants prior to coating. The surfaces shall be sanded using 120
grit paper to dull previously applied coatings and to smooth surface imperfections prior to s
coating. Always follow manufacturers technical data sheet instructions unless otherwise
specified.
x
(1) One coat: Odorless Oil Primer /Sealer manufactured by Zinsser Co.
* Spot prime as needed on bare or damaged areas
*Primer color to be White
*Apply by brush or 3/16" shed resistant mohair or foam roller cover
(2) Two coats: Devguard 4308 Alkyd Industrial Gloss Enamel
• Finish color to be 4308 -9990 Black
• Apply by brush or 3/16" shed resistant mohair or foam roller cover
i
202) Re -lamp existing sales area light fixtures with GE SP41 ECO lamps. Re -lense existing 2x4 fixtures with I
acrylic lenses.
f
203) Install LED lights on all cooler doors. Install G99 shelf extension brackets. (By The Pantry).
204) Install new ceiling tile. Armstrong #763 "Georgian" for 24" x 48" grid patterns and Armstrong #764
"Georgian for 24" x 24" grid patterns. Replace all HVAC registers.
205) Cut sales counter and elevated platform back per plans. Relocate existing Veederroot to back room,
relocate existing PDI computer.
206) Build 64" high wall with ramp as indicated on plans. Provide and install oak cap on top of wall.
207) Install new rubber flooring on sales counter platform. Johnsonite Roundel Rubber Floor Tiles — Raised
Round style. Color to be black. Remove VCT the and prep raised platform per mfg installation specs.
Provide and install s.s. edge trim on all platform step -ups.
200) Install cigarette flex frames behind sales counter or modify existing fixures to be 60" high. (By The
Pantry). Height to be noted on plans. G.C. to clear area for an easy installation.
)
a
208) Install a 24" x 36" black picture frame to display all store operating licenses. Locate on walls with the
Silver Stone wall covering close to the sales counter. Confirm location with Pantry Project Manager.
Frame provided by The Pantry.
209) Install an 18" x 24" black framed employee bulletin board to display all store labor schedules and t
reports. Locate close to PDI computer. Confirm location with Pantry Project Manager. Frame provided t
by The Pantry. l
5
210) Grind down and polish terrazzo floor in sales area and restrooms.
l
Bean Street Coffee Area
300) Re- furbish existing wood cabinets - Remove doors and install plastic laminate on cabinet frames - e
Formica 2200 Dark Chocolate, Matte Finish. Install new cabinet doors wrapped with Formica 3699 -58
Rattan Cane plastic laminate — run grain vertically. Rattan Cane to be installed on cabinet ends as well.
(By The Pantry).
r
Printed: 08/13110 Master updated: 7/2/10 Page 2 of 5
t
I
`s
f
Store #: 3954 Scope of Work
301) Provide and install Daltile Modern Dimensions 412 modular (stacked vertically) 0771 -MT Cityline Kohl
from countertop up to 36" above countertop level. Provide and install Daltile Modern Dimensions
412 modular (stacked vertically) 0790 Arctic White from 36" above countertop to underside of
horizontal soffit. Grout to be Custom Building Products, Winter Gray # 335.
j
302) Receive and install 60" long trench drain as provided by The Pantry. Cut top as needed and connect to
existing under counter drain.
303) Provide and install under counter sump pump that can handle high heat liquids. Pipe overhead to
nearest utility sink. Connect to new sink (By G.C) and drain trough. Liberty Model 405 Commercial 115
volt. f
304) Receive and install (3) Wilbur Curtis twin brewers per plans.
305) Receive and install new Royston built -in cup dispensers with black rings. Remove plastic condiment
holders that are built into cabinet and replace with cup dispensers. z
F
F
306) Receive and install new countertop condiment holders.
307) Provide and install new solid surface top. Wilsonart Gibralter Caramel Melange — 9033ML 13MM. (By
The Pantry).
308) Install interior decor per design plans. Review adhesive spec sheet and mfg recommended installation
instructions with Pantry Project Manager. (By The Pantry). f
Fountain Area
400) Re -build fountain wall for built-in fountain and FCB machines. Wrap all edges with stainless steel E
corners, 18 gauge with a kick, brush finish. Receive and install built -in cup dispensers add built -in lid /
straw holders. Review dimensions with Pantry Project Manager prior to starting work.
)
401) Re- furbish existing wood cabinets - Remove doors and install plastic laminate on cabinet frames -
Formica 2200 Dark Chocolate, Matte Finish. Install new cabinet doors wrapped with Formica 3699 -58
Rattan Cane plastic laminate — run grain vertically. Rattan Cane to be installed on cabinet ends as well.,
(By The Pantry).
402) Receive and install new Lancer FS -44 fountain and (2) remote ice makers. (Electrical / plumbing by
G.C., equipment install by Pantry).
403) Receive and install new Royston built -in cup dispensers with black rings. I
)
Grill Depot Area
(
500) Receive and install wood cabinets per plans and details. Receive and install slat wall shelves (By The
Pantry).
)
501) Receive and install new solid surface top. Wilsonart Gibralter Caramel Melange — 9033ML 13MM. (By
The Pantry).
Sales Counters
600) Receive and install (2) sales counter merchandisers provided by The Pantry
;
Printed: 08/13/10 Master updated: 7/2/10 Page 3 of 5
E
t
F
Store #: 3954 Scope of Work
% r
601) Re- furbish existing wood cabinets - Remove doors and install plastic laminate on cabinet frames ,
Formica 2200 Dark Chocolate, Matte Finish. Install new cabinet doors wrapped with Formica 3699 -58
Rattan Cane plastic laminate — run grain vertically. Rattan Cane to be installed on cabinet ends as well.
(By The Pantry).
F
602) Re- position all sales counter equipment per plans. Locate all equipment prior to cutting in grommets. s
(Equipment relocation by The Pantry, Electrical by G.C.). t
603) Provide and install new solid surface top. Wilsonart Gibralter Caramel Melange — 9033ML 13MM. (By
The Pantry).
604) Relocate all power poles coming down in the center of the sales counter. Verify location with Pantry
Project Manager.
605) Relocate all POS equipment per plans.
Restrooms
g
700) Thoroughly sanitize restrooms with a chemical enzyme cleaner — coordinate with Operations.
)
701) Remove condom dispensers and repair holes in wall.
F
f
702) Replace all tiles with holes as necessary. Reseal and anchor all restroom fixtures.
703 Remove Urinal and cap utilities. Replace all damaged or missing tiles.
New Eguil ment Provided by The Pantry
1) Barker 6' -4" self- contained upright FRESH case — 208v, 1 phase circuit.
2) (2) Sales counter merchandisers.
3) Soda dispenser — Lancer FS -44 120V, 5.2A outlet, 120V, 7.2A outlet for carbonator, %:" water line with
shut off valve tee of off 3/4" main line. (Installed by The Pantry).
4) Remote Ice machine — Hoshizaki chewable ice. 120V, 20A circuit at ice machine with control wiring to
remote condenser. %:" water line with shut off valve from scale inhibitor. (Installed by The Pantry).
t
5) Remote Ice machine — Manitowoc Cubed Ice IB684C 22" wide. 115V, 15A circuit at ice machine with
control wiring to remote condenser. %:" water line with shut off valve from scale inhibitor. (Installed by The
F
Pantry).
6) (2) 3 -Head FCB machine — 245V, single phase, 3 wire, 20amp, Uses NEMA #L -620 -R receptical. (Installed by
The Pantry). Electrical by GC
7) Wilbur Curtis Tea Brewer — Complete with 3 urns and tray. 120V, 20A circuit each with single outlet, % :" t
water line with shut off valve for each unit tee of off 3/4" trunk line.
)
8� Iced Coffee -120V, 20A circuit each with single outlet; % :" water line with shut off valve for each unit tee of (
off 3/4" trunk line.
(
Page 4 of 5
Printed: 08/13/10 Master updated: 7/2/10
f
t
Store #: 3954 Scope of Work
9) (2) Hot dog grills —120V, 14.OA . Star 45SCBB w/ duratec rollers, bun warmer drawer and sneeze guard.
(Pull from stock).
10) Refrigerated condiment station — APW Wyott —120V, 8.OA, 1.01
11) (2) 24" countertop condiment holder for the coffee area.
12) (4) Countertop Lid Savers to be placed underneath condiment racks.
13) (3) Wilbur Curtis twin brewers — 220V, 30A circuit each with single outlet, %" water line with shut off valve
for each unit tee of off 3/4 trunk line.
14) 60" drain trough.
15) Creamer machine —120V, 6.OA. (Equipment provided by Marketing).
16) Pastry Case —120V (Provided by Marketing).
d
17) Bean Street decor package.
18) Full Store Interior Decor package.
r
19) Beer Cave Racking.
k
r
E
{{
t'
E
gg
¢ f 3
4
g
t
F
i
B
1
5
f
g
k
k
f
Printed: 08/13/10 Master updated: 7/2/10 Page 5 of 5 g
F
- -' �, --- SHELF 'ME 9Elf 7111[ 9El/
co cn
rn
G _
CO I a <•� :m
0
0 ; (D) B"m our x
Ny - ----- 9--------- - - - - -- 0
T� ' � /a : R rink
cn
..'� 7 SHELF §'
v
INS
1 0 � I
0
' I I
^• L7 o
i ,� , I i
I ,
w[
SHELF
n m _ H
• m H
is
g g
�� •
V�
t
i0 -
I r� I
I I
r - -- ... -- L I r
Y�
(5)(E) 3! toDl[x DOOPM S ,
L L
Ala : As :::
r�
tv
� # A ll.
� I I I I
••.•s (E) 3..y_ 1..! ••••• ; (E) 31.N ([) -- (E 4 (111..1!
Op1UQ YIC ME �[ 'ME I '
I I 9Elf 9Klf 9Qf _ 9EIf '
I I I C
L-------- - - - - -- — — — — — — — — — — — — — — — J
f
t
r
O
co
PIP. 0
' I Yyfi -_----- -- --- --- ---- - - - - -
o + 3
(D N O Z
p� C�cn
CD
i
m
cn
Ae
g � e
r 3 y
A '
F ' g
` E
�■ � m \yin, F+
g
c , D A I —4; 4
CD m 3 3
ntto LM a i
I I Cl o l
I I °{
El
I 1 ti� I
I I • I m
L s
e
CIWT
I � I
GO'
RUH W. for
0 0 A I
LJ
(") N•eo' �[[" ")3.'.� ��R uv[
L EE I�a...ss tt) �••w R) x�,.r �(O a
Gk E W[ gds WIC 9d/ Q 9df 1ME gds
L - — - — - — - — - — - — - — - — - — - — - — - - — - — - — - — - — - — - — - — - — - — - — - .�I
E
c
F